Tell us about the job
Takes about a minute. No obligation.
A contractor quoting a furnace installation in Clark County starts with a load calculation that reflects what the climate actually does here, not a default figure pulled from a regional chart. 124 severe weather events were recorded in Clark County, Ohio between 2015 and 2024. At that rate, severe weather is a standing condition rather than an occasional interruption, and a furnace sized against mild assumptions runs short of capacity when the seasons demand the most. Duct layout, equipment rating, and heat exchanger spec all follow from that calculation. Get those wrong at installation and no amount of maintenance recovers them.
Existing ductwork is the first thing a contractor has to assess in a Clark County furnace installation, and the age of the housing stock is why. Half the homes in Clark County, Ohio were built in 1963 or earlier (2020-2024 ACS 5-year). Ductwork put in for an older system carries different static pressure than a new furnace expects, and sheet metal sized for one unit may restrict airflow through another. Electrical service is a second check: a panel original to a house of that vintage may not have the capacity a modern furnace and its controls draw. The equipment choice follows from what the house already contains.
What Gets Installed With a New Furnace
The furnace itself sits in the basement, utility room, or crawl space and is the piece doing the work: a burner assembly fires inside it, a heat exchanger captures that heat, and a blower motor pushes conditioned air out through the house. The flue pipe runs from the furnace to an exterior wall or roof and carries combustion gases out.
The thermostat mounts on an interior wall where a homeowner can reach it and tells the furnace when to run. Alongside the furnace, a contractor also installs the air filter housing, the blower compartment door and its safety switches, and the gas line connection that feeds the burner.
The drawing shows a typical layout, and a licensed contractor determines exactly what applies to your home's configuration.
Get matched in Clark CountyClark County, by the numbers
124 severe weather events were recorded in Clark County, Ohio between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Clark County, Ohio were built in 1963 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesClark County, Ohio holds 61,126 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 69.4% of the occupied homes in Clark County, Ohio (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules on the Books for Clark County, Ohio18 sourced standards and codes
What the Installation Actually Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in Clark County, Ohio
An Ohio home construction services contract must include a copy of the supplier's certificate of insurance showing general liability coverage of not less than two hundred fifty thousand dollars.
In Ohio a home construction service means the construction of a residential building, including the repair, improvement, remodel or renovation of an existing structure, and does not include construction on a structure containing four or more dwelling units except for work on an individual dwelling unit within it.
A home construction service supplier in Ohio is defined as a person who contracts with an owner to provide home construction services for compensation and who maintains a general liability insurance policy of not less than two hundred fifty thousand dollars.
The Ohio construction industry licensing board issues state licenses to individuals as heating, ventilating and air conditioning contractors, refrigeration contractors, electrical contractors, plumbing contractors and hydronics contractors.
An Ohio board of county commissioners may accept a valid and unexpired Chapter 4740 license held by a heating, ventilating and air conditioning contractor toward its own licensing requirements for work on one-, two-, or three-family dwelling houses.
An Ohio board of county commissioners may adopt rules licensing heating, ventilating and air conditioning contractors who are not required to hold a state license under Chapter 4740.
In Ohio municipal law a specialty contractor includes heating, ventilating and air conditioning contractors, refrigeration contractors, electrical contractors, plumbing contractors and hydronics contractors.
An Ohio board of county commissioners may not register a specialty contractor who is required to hold a license under Chapter 4740 but does not hold a valid one.
An Ohio municipal corporation may not register a specialty contractor who is required to hold a license under Chapter 4740 but does not hold a valid one.
In Ohio building law a residential building means a one-family, two-family or three-family dwelling house and any accessory structure incidental to it, and does not include an industrialized unit, a manufactured home or a mobile home.
Ohio's contractor licensing chapter reaches only work on a construction project, and a construction project is defined to exclude residential buildings, so an HVAC contractor working on a one-, two-, or three-family dwelling in Ohio falls outside the state licensing requirement.
Violating Ohio's contractor licensing prohibition is a minor misdemeanor on a first violation and a misdemeanor of the fourth degree on subsequent violations.
Under Ohio law no person may act as or claim to be a type of contractor that Chapter 4740 licenses unless that person holds a license issued under that chapter.
In Ohio a home construction service supplier may not perform a home construction service costing twenty-five thousand dollars or more without entering into a written home construction services contract with the owner, unless the supplier and owner enter into a cost-plus contract.
Severe Weather Events in Clark County
Weather in Clark County puts real demands on heating equipment. How hard a furnace has to work over its life is a local fact, and the pattern of severe weather here is part of what shapes that load.
124 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.