Tell us about the job
Takes about a minute. No obligation.
Sizing a furnace for Crawford County starts with what the climate actually asks of it, and that question has a real answer. 72 severe weather events were recorded in Crawford County, Ohio between 2015 and 2024. At that rate, severe weather lands here often enough to matter in a spec but not so relentlessly that it overrides every other variable. A contractor quoting a new furnace here will treat duct layout, equipment placement, and load calculation as the decisions that determine how well the system runs, because the weather alone does not settle them.
Ductwork laid down for an early postwar furnace was sized and routed for that furnace, and what fits the old unit often fights the new one. Half the homes in Crawford County, Ohio were built in 1959 or earlier (2020-2024 ACS 5-year). A contractor installing a replacement furnace in stock like this has to assess whether the existing supply and return runs will carry the airflow a modern unit needs, and whether the electrical service will handle the draw, before anything else on the job is priced or scheduled. Those are the two variables the age of the housing puts on the table.
What Gets Installed With a New Furnace
The furnace itself sits in the basement, utility room, or crawlspace and is the piece that produces heat. A heat exchanger inside it warms the air that will move through the house, and a burner assembly feeds it fuel. The blower motor, housed in the same cabinet, pushes that warmed air out.
The flue pipe runs from the furnace to an exterior wall or up through the roof, carrying combustion gases out of the house. A gas valve and ignition assembly connect to the fuel supply, and a thermostat mounts on an interior wall to tell the whole system when to run.
The drawing beside this shows a typical layout, and a licensed contractor determines what applies to your specific home.
Get matched in Crawford CountyCrawford County, Ohio, by the numbers
72 severe weather events were recorded in Crawford County, Ohio between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Crawford County, Ohio were built in 1959 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCrawford County, Ohio holds 19,812 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 73.1% of the occupied homes in Crawford County, Ohio (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules for Crawford County, Ohio18 codes & standards
What the Installation Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in Crawford County, Ohio
An Ohio home construction services contract must include a copy of the supplier's certificate of insurance showing general liability coverage of not less than two hundred fifty thousand dollars.
In Ohio a home construction service means the construction of a residential building, including the repair, improvement, remodel or renovation of an existing structure, and does not include construction on a structure containing four or more dwelling units except for work on an individual dwelling unit within it.
A home construction service supplier in Ohio is defined as a person who contracts with an owner to provide home construction services for compensation and who maintains a general liability insurance policy of not less than two hundred fifty thousand dollars.
The Ohio construction industry licensing board issues state licenses to individuals as heating, ventilating and air conditioning contractors, refrigeration contractors, electrical contractors, plumbing contractors and hydronics contractors.
An Ohio board of county commissioners may accept a valid and unexpired Chapter 4740 license held by a heating, ventilating and air conditioning contractor toward its own licensing requirements for work on one-, two-, or three-family dwelling houses.
An Ohio board of county commissioners may adopt rules licensing heating, ventilating and air conditioning contractors who are not required to hold a state license under Chapter 4740.
In Ohio municipal law a specialty contractor includes heating, ventilating and air conditioning contractors, refrigeration contractors, electrical contractors, plumbing contractors and hydronics contractors.
An Ohio board of county commissioners may not register a specialty contractor who is required to hold a license under Chapter 4740 but does not hold a valid one.
An Ohio municipal corporation may not register a specialty contractor who is required to hold a license under Chapter 4740 but does not hold a valid one.
In Ohio building law a residential building means a one-family, two-family or three-family dwelling house and any accessory structure incidental to it, and does not include an industrialized unit, a manufactured home or a mobile home.
Ohio's contractor licensing chapter reaches only work on a construction project, and a construction project is defined to exclude residential buildings, so an HVAC contractor working on a one-, two-, or three-family dwelling in Ohio falls outside the state licensing requirement.
Violating Ohio's contractor licensing prohibition is a minor misdemeanor on a first violation and a misdemeanor of the fourth degree on subsequent violations.
Under Ohio law no person may act as or claim to be a type of contractor that Chapter 4740 licenses unless that person holds a license issued under that chapter.
In Ohio a home construction service supplier may not perform a home construction service costing twenty-five thousand dollars or more without entering into a written home construction services contract with the owner, unless the supplier and owner enter into a cost-plus contract.
Severe Weather Events in Crawford County
Crawford County's weather puts real demands on heating equipment over time. A furnace sized and installed for local conditions holds up better than one that was not.
72 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.